L jet info - running rich

Post your E12 technical questions and comments here. Please, no off-topic posts.

Moderators: Mike W., Pierre

Post Reply
garyinwestoz
Posts: 118
Joined: Thu Jan 29, 2009 9:05 pm
Location: perth, australia
Contact:

L jet info - running rich

Post by garyinwestoz » Wed Feb 06, 2019 5:45 am

found this today

http://www.injectronics.com.au/assets/Uploads/T0067.pdf

" Document number: T0067
TECHNICAL BULLETIN
For further technical information regarding testing, repairs or to search for New or Remanufactured Automotive electronic products, please visit www.injectronics.com.au, call our office on (+613) 8792 6999, or email sales@injectronics.com.au

Make: BMW

Model: 5 & 7 series, early to mid 80’s Subject: Running rich

Some early to mid 1980 BMW 6 cylinder engines used the Bosch L Jetronic system. This was the earliest of the air flap type engine management systems and used a 35 pin ECM.
The ECM pin 4 monitors crank signal from the starter motor and uses this signal to give start up enrichment. There should be zero volts at this pin when the engine is running or the key is just in the on position. When cranking there should be a crank voltage of approx 10 volts depending on the voltage drop.

Injectronics has had many customers call to say they have a running rich BMW and upon questioning we have learnt that starter motor work has been performed. In some cases a relay has been wired into the starter circuit, which causes a voltage to be present on pin 4 when the engine is running. This of course will make the engine run rich. To confirm this is your fault check the voltage at pin 4 with the engine running and it should be zero volts. If there is a voltage present, disconnect the relay or temporarily cut the wire going to pin 4.

T0067.doc

This publication is distributed with the understanding that the authors, editors and publishers are not responsible for the results of any actions or works of whatsoever kind undertaken on the basis of information contained in this publication, nor for any errors or omissions contained herein. The publishers, authors and editors expressly disclaim all and any liability to any person whomsoever whether a purchaser of this publication or not in respect of anything and of the consequences of anything done or omitted to be done by any such persons in reliance, whether whole or partial upon the whole or any part of the contents of this publication. Injectronics Australia Pty Ltd. © Copyright 2001.
77 528i -4 speed manual getting rusty
76 525 - 4 speed manual LPG and holley carb
81 528i - auto - to be relicensed with a 3.5 (83 735i)
79 SA ? 528i auto
79 528i auto parts car
86 525e 5 speed manual

User avatar
Mike W.
Posts: 2444
Joined: Wed Aug 30, 2006 12:12 am
Location: Sonoma County

Re: L jet info - running rich

Post by Mike W. » Wed Feb 06, 2019 1:59 pm

I did that by accident when I put L jet off an E12 onto a Bavaria. It wasn't rich, it was pig rich, black smoke rich. It ran, but not well. Didn't take too long to figure it out going over the schematic.
Mike W.



1980 528i, 3.5 euro, 5 speed conversion
1981 528i, 3.6, Recaros and more. Project
1998 328is, quick and efficient, but not satisfying
2000 528iit, Vacation mobile/wife's grocery getter

Post Reply